Quest for Fiber: Colores! Colores!
Since I arrived in Calca, I have been trying to find a natural dyeing workshop to learn how the Quechua traditionally dyed their fiber. I was especially interested in a four-day homestay in a small village sponsored by an organization called Awamaki which is located in Ollantaytambo. However, they would not have any excursions until May, after I leave Peru.
But, thanks to my hosts at Casa Willkamayo, where I am living, I was referred to a local organization only blocks from here: Apulaya, which is run by Emerita Bucher and her husband, Valerio Fernandez. Emerita emailed me one day to say that a half-day workshop would be offered on April 12, and so I finally got the opportunity to learn about this fascinating subject first-hand from Apolonia Coronel, a sweet Quechua woman from the high Andean community of Ranra.
I arrived promptly at 9:00 am to find Emerita and Apolonia busy starting the fire and heating water over a traditional Andean stove. (I want one of those little stoves in my yard!) Emerita put me to work stripping the leaves from a chilca plant which would yield a green color.
The other workshop participant, Yiqian, an artist from China, began crushing dried cochineal, an insect parasite of nopal-type cacti which yields bright red. The other dye we would be using was quiswar flowers for gold or yellow.
A very interesting article on the history of cochineal can be found here. Because it is so difficult to cultivate and harvest the insects, the dye is very expensive.
After we finished stripping the chilca leaves, Apolonia filled one of the pots so full with them that I wondered if there would be room for the yarn.
She had already prepared several hanks of her handspun wool from sheep that are raised at Apulaya.
The Quechua women spin “singles” (unplyed yarn) and then, holding two singles together without plying them, they create a hank by running the two yarns in figure-eights. I learned later that this keeps the yarn from tangling so bad when it is stirred around in the dye bath. And because the yarn is not plied, the dye can penetrate more evenly through the fiber.
Only after the yarn is dyed and dried, do they ply the two singles together. And despite how tangled the hank looks, believe it or not, it is very easy to pull the yarn apart to begin the plying process, particularly because the two single strands were hanked together.
The chilca requires a mordant to help set the dye and to make different shades of green. Colpa, a local mineral, was the mordant we used. Later, eucalyptus and molle leaves were added to the dye bath to see if we would get a different color of green. Eucalyptus is not a native Andean plant, but has been imported for lumber and firewood and it grows everywhere here in the Sacred Valley.
We used lemon salt as a mordant for the cochineal. If you use an acid mordant, the color is brighter; if you use an alkali mordant, the color is darker. Our lemon salt mordant resulted in a nice purple. The quiswar did not require a mordant, and the bath can be used several times—each successive hank is lighter in color.
I brought a few sample hanks of some pure alpaca yarn that I had purchased in Arequipa to put in the dye baths. (See Revisiting Arequipa’s Fiber Mills.)
One of them went into the chilca/ eucalyptus/molle bath; one to the cochineal bath; and the third one to the quiswar.
The hanks were allowed to boil in the baths for about 15 minutes and when we fished them out, the colors were remarkable!
We took them over to a canal with running water to wash out the excess dye and hung the hanks on a tree to dry.
Along with my three little test hanks, I brought home one of Apolonia’s hanks from the quiswhar pot which turned out to be a beautiful gold. I almost could not wait until it was dry to ply the singles together. I am working it into a chullo (ear-flap hat) that I am making using Andean symbols and knitting techniques that I have learned here.
This was one of the highlights of my stay in Calca. I look forward to learning more about natural dyeing when I get home and finding out what colors our local plants in the Pacific Northwest US yield.
Other Blog Posts You May Find Interesting
Quest for Fiber: Picky about my Hentilagets on Bressay
You find hentilagets where sheep have rubbed up against walls or fences, but the best pieces for spinning are on the ground. I found that most hentilagets are rubbish. They have been weathered too much and are slightly felted,
Quest for Fiber: Alpaca and Acrylic and Títeres
On my third day in Arequipa, Adela took me to Michell’s Fiber Mill. There is an outlet store there with all kinds of alpaca yarn at very good prices. Adjacent to the mill is Mundo Alpaca, a museum showing the process of preparing alpaca fleeces for market—both by hand and by machine.
Quest for Fiber: The New Lanark Cotton Mill
I spent the entire day walking through the exhibits showing the living quarters, spinning machinery, children’s living conditions, the non-profit company store, and today’s working spinning mill making the New Lanark Wool Yarn.
1 thought on “Quest for Fiber: Colores! Colores!”
freaking amazing!